1. Introduzione
This manual provides essential information for the safe and efficient operation, installation, and maintenance of your True TBB-2G-HC-LD Commercial Back Bar Refrigerator. Please read all instructions carefully before using the appliance to ensure proper function and longevity.
The True TBB-2G-HC-LD is a two-section back bar refrigerator designed for commercial use, featuring two swinging glass doors, a black exterior, and operating on 115V power. It is capable of holding up to 88 six-packs of 12-ounce cans or two half-barrel kegs, maintaining temperatures between 33°F and 38°F using R290 hydrocarbon refrigerant.
2. Informazioni sulla sicurezza
ATTENZIONE: per ridurre il rischio di incendi, scosse elettriche o lesioni, seguire sempre le precauzioni di sicurezza di base.
- Ensure the unit is connected to a properly grounded 115V/60Hz/1ph electrical outlet with a NEMA 5-15P plug. Do not use extension cords.
- Non conservare sostanze esplosive, come bombolette spray con propellente infiammabile, in questo apparecchio.
- Mantenere libere da ostruzioni le aperture di ventilazione nell'involucro dell'apparecchio o nella struttura integrata.
- Non utilizzare dispositivi meccanici o altri mezzi per accelerare il processo di sbrinamento, diversi da quelli raccomandati dal produttore.
- Non danneggiare il circuito refrigerante.
- Le riparazioni devono essere eseguite esclusivamente da personale di assistenza qualificato.
- This appliance is heavy (approximately 395 lbs). Use appropriate lifting techniques and equipment during installation to prevent injury.
3. Disimballaggio e installazione
3.1 Disimballaggio
- Rimuovere con cautela tutto il materiale di imballaggio, compresi nastro adesivo e pellicola protettiva.
- Inspect the refrigerator for any shipping damage. Report any damage immediately to the carrier and your dealer.
- Rimuovere tutti i materiali di imballaggio interni e gli accessori.
3.2 Ubicazione e posizionamento
Select a location that is level, stable, and strong enough to support the unit's weight (395 lbs) when fully loaded. Ensure adequate air circulation around the unit.
- Dimensioni: 58 7/8" W x 29 7/8" D x 37" H. Allow sufficient clearance for door swing and ventilation.
- Avoid direct sunlight or proximity to heat-generating appliances.
- Ensure the unit is level using a spirit level and adjusting the feet if necessary.
3.3 Collegamento elettrico
The unit requires a dedicated 115V/60Hz/1ph electrical supply with a 2.8 amp draw and a NEMA 5-15P plug. Do not use adapters or extension cords. Consult a qualified electrician if you are unsure about your electrical supply.
3.4 Pulizia iniziale
Prima del primo utilizzo, pulire le superfici interne ed esterne con un detergente delicato e acqua tiepida. Risciacquare abbondantemente e asciugare completamente.
4. Funzionamento
4.1 Accensione
After installation and initial cleaning, plug the unit into the dedicated electrical outlet. The compressor will start, and the interior LED lighting will illuminate.
4.2 Controllo della temperatura
The unit is designed to maintain temperatures between 33°F and 38°F. Temperature adjustments are typically managed by a factory-set thermostat. Refer to the digital thermometer for current internal temperature.
4.3 Caricamento del frigorifero
The refrigerator can hold up to 88 six-packs of 12-ounce cans or two half-barrel kegs. It features four black PVC-coated shelves, adjustable in 1/2-inch increments, to accommodate various product sizes.
Figura 1: Fronte view of the True TBB-2G-HC-LD Commercial Back Bar Refrigerator. This image shows the unit with its two glass doors, revealing multiple shelves stocked with various bottled and canned beverages. The black exterior and stainless steel countertop are visible.
4.4 Caratteristiche della porta
- Porte in vetro: Double-pane thermal glass provides visibility of products while maintaining insulation.
- Magnetic Gaskets: Ensure a tight seal to prevent cold air loss.
- Serrature delle porte: For securing contents.
- Threshold Protector: Prevents damage to the cabinet when loading or unloading heavy items like kegs.
5. Manutenzione e pulizia
5.1 Pulizia regolare
- Interno: Clean the stainless steel interior floor and walls regularly with a mild, non-abrasive cleaner and warm water. Rinse and dry thoroughly to prevent odors and maintain hygiene.
- Esterno: Wipe down the black laminate vinyl exterior and stainless steel countertop with a damp panno e detergente delicato. Evitare detergenti abrasivi che potrebbero danneggiare la finitura.
- Porte in vetro: Use a glass cleaner for streak-free visibility.
- Guarnizioni delle porte: Inspect and clean door gaskets regularly to ensure they are free of debris and maintain a proper seal. Replace worn or damaged gaskets promptly.
5.2 Pulizia della serpentina del condensatore
The unit features a reverse condensing fan motor that helps remove debris from the condensing coil. This mechanism activates for 20 seconds each time the compressor turns on, directing air towards the coil to dislodge dirt and dust. While this reduces buildup, regular manual inspection and cleaning are still recommended for optimal efficiency.
- Scollegare l'alimentazione dall'unità prima di pulirla.
- Access the refrigeration system by removing the front grille and sliding it out.
- Use a stiff brush or vacuum cleaner to remove any remaining dust and debris from the condenser coil fins.
- Reinstallare la griglia e ripristinare l'alimentazione.
6. Risoluzione Dei Problemi
Prima di contattare l'assistenza, riview i seguenti problemi comuni e le relative soluzioni:
| Problema | Possibile causa | Soluzione |
|---|---|---|
| Unità non raffreddante | No power; thermostat set too high; condenser coil dirty; door left ajar. | Check power connection and circuit breaker; verify thermostat setting; clean condenser coil; ensure doors are fully closed. |
| Rumore eccessivo | Unità non a livello; ventola ostruita; componenti allentati. | Level the unit; check for obstructions around fan blades; contact service if noise persists. |
| Water on floor (leaking) | Drain line clogged; excessive humidity. | Clear drain line; ensure doors are not left open frequently. |
| Doors not sealing properly | Gaskets dirty or damaged; unit not level. | Clean or replace gaskets; level the unit. |
Se le procedure di risoluzione dei problemi non risolvono il problema, contattare personale di assistenza qualificato.
7. Specifiche
| Caratteristica | Specificazione |
|---|---|
| Modello | TBB-2G-HC-LD |
| Marca | VERO |
| Dimensioni (L x P x A) | 58 7/8" x 29 7/8" x 37" (1494 mm x 759 mm x 940 mm) |
| Peso dell'articolo | 395 libbre |
| Capacità | 88 six-packs (12-oz cans) or 2 half-barrel kegs / 15.5 Gallons |
| Numero di porte | 2 (Swinging Glass Doors) |
| Scaffali | 4 (Black PVC-coated, adjustable in 1/2" increments) |
| Refrigerante | R290 Idrocarburo |
| Intervallo di temperatura | Da 33°F a 38°F |
| Elettrico | 115V/60Hz/1ph, 2.8 Amps, 1/4 HP |
| Tipo di spina | NEMA 5-15P |
| Finitura esterna | Black Laminate Vinyl |
| Finitura interna | Stainless Steel Floor, Galvanized Interior |
| Isolamento | poliuretano espanso in loco |
| Caratteristiche speciali | LED Interior Lighting, Door Locks, Scratch Resistant, Frost Free Defrost |
Figure 2: Elevation diagram providing front view dimensions of the True TBB-2G-HC-LD refrigerator in inches and millimeters. Key measurements include overall width (58 13/16"), height (37"), and the 3" clearance from the floor.
Figura 3: Piano view diagram illustrating the top-down dimensions of the True TBB-2G-HC-LD refrigerator. It shows the depth (28 13/16") and the swing radius of the two doors when fully open.
8. Garanzia e supporto
8.1 Informazioni sulla garanzia
This True TBB-2G-HC-LD refrigerator comes with a 7-year Parts & Labor warranty e un 7-year Compressor warrantySi prega di conservare la prova d'acquisto per eventuali reclami in garanzia. La garanzia copre difetti di materiali e fabbricazione in normali condizioni di utilizzo e manutenzione.
8.2 Assistenza clienti
For technical assistance, service requests, or warranty inquiries, please contact your authorized True Refrigeration dealer or the manufacturer's customer service. Have your model number (TBB-2G-HC-LD) and serial number ready when contacting support.